ETV Joint Verification Statement for GORE Baghouse Filtration Products.

Plant retrofitted old ESP system to baghouse in 2002 in order to increase productivity, reliability, and emissions. Process required use of addition of soda ash in order to facilitate grate nodule formation, which affected pressure drop.

Cement plant in China using non-membrane Nomex® filter bags was experiencing high pressure drop and short bag life. Poor performance was resulting in high energy consumption and costly maintenance.

Plant increased pre-heater fan capacity in order to increase productivity. The increased airflows resulted in higher pressure drop across the baghouse. Since installation of GORE Filter Bags, filter lifetime is over 12 years and has exceeded performance expectations for both airflow and pressure drop.

After modifications and adjustments to the baghouse and separator were completed, the plant achieved a production rate of 80 tph, which exceeded the rated specifications for the separator by almost 10 tph.

Design capacity of the mill was 100 tons/hr, but when the load increased to higher than 93 tons/hr, the differential pressure increased, causing the gas flow rate to decrease. Decrease of the flow rate caused the total productivity of the mill to decrease.

In 1997, a plant modernization program was initiated to improve fuel efficiency and environmental performance and two older wet kilns were permanently shut down. In 1999, a new 3,000 tons per day kiln line with a 5-stage precalciner was commissioned. A Solios (formerly Procedair) TGT baghouse was built and high performance filters were required to meet efficiency and environmental targets.

Plant installed new baghouse and wanted to obtain optimum performance with long-term reliability. GORE® High Durability Filters were used in new installation, met all performance requirements, and provided 10-year performance life. Plant wanted to maintain high system productivity when choosing next set of filter bags.

Plant installed new baghouse and wanted to obtain optimum performance with long-term reliability. They also wanted high system productivity with low pressure drop to save on energy costs.

Learn about the operating experience of a dry scrubber/baghouse at the ShuLin waste-to-energy incineration plant in Taiwan in this eight page article.